Product ID:763 RUST TRANSFORMER (BULK)
MSDS Date:04/05/1998
FSC:8030
NIIN:00N010671
MSDS Number: CJPCT

A W CHESTERTON COMPANY

225 FALLON ROAD
STONEHAM, MA 02180-2999
US

Emergency Phone: 800-535-5053

Info Phone: 781-438-7000

Cage: 71431

CHESTERTON A W CO

STONEHAM, MA 02180-9101 US

Telephone: 781-438-7000/800-535-5053

Cage: 71431

ETHYLENE GLYCOL

CAS: 107-21-1

RTECS: KW2975000

ACGIH TLV: 100 MG/M3

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

ISOPROPYL ALCOHOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

BARIUM

CAS: 7440-39-3

RTECS: CQ8370000

OSHA PEL 0.5 MG/M3

ACGIH TLV: 0.5 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: SEVERE EYE AND SKIN
IRRITANT; MAY CAUSE BURNS. EXCESSIVE INHALATION OF VAPORS MAY
RESULT IN DIZZINESS, HEADACHE AND OTHER CENTRAL NERVOUS SYSTEM
EFFECTS. CHRONIC EFFECTS: PROLONGED OR R EPEATED SKIN CONTACT MAY
DEFAT THE SKIN AND CAUSE DERMATITIS. REPEATED OVEREXPOSURE TO
ETHYLENE GLYCOL CAN CAUSE KIDNEY AND LIVER EFFECTS.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, ADMINISTER
ARTIFICIAL RESPIRATION. CONTACT PHYSICIAN. SKIN CONT: WASH WITH
SOAP AND WATER. WASH CLOTHING BEFORE REUSE. CONSULT PHYSICIAN. EYE
CONT: F LUSH FOR AT LEAST 15 MINUTES WITH LARGE AMOUNTS OF WATER.
CONSULT PHYSICIAN. INGESTION: DO NOT INDUCE VOMITIING. IF
CONSCIOUS, DILUTE STOMACH CONTENTS WITH LARGE QUANTITIES OF WATER.
CONTACT PHYSICIAN IMMEDIATELY. ADVICE TO PHYSICIAN: TREAT
SYMPTOMS.

Flash Point Method:PMCC
Flash Point:=34.C, 93.2F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE. HAZCHEM EMERGENCY ACTION CODE: 3Z.

Spill Release Procedures:EVACUATE AREA. (PROVIDE ADEQUATE VENTILATION.
CONTAIN SPILL TO A SMALL AREA. FLUSH AWAY FROM IGNITION SOURCES
WITH WATER. PICK UP WITH ABSORBENT MATERIAL(SAND, SAWDUST, CLAY,
ETC) AND PLACE IN A SUITA BLE CONTAINER FOR DISPOSAL. KEEP OUT OF
SEWERS, STREAMS AND WATERWAYS.
Neutralizing Agent:DILUTE SOLUTION OF BLEACH.

Handling and Storage Precautions:WASH BEFORE EATING, DRINKING OR
SMOKING. CONTAINERS MUST BE GROUNDED AND BONDED DURING POURING.
FLAMMABLE. CAUSES BURNS. AS WITH ANY SIMILAR PRODUCT, IF SWALLOWED
IN LARGE QUANTITIES. THIS PRODUCT COU LD BE HARMFUL OR FATAL.
Other Precautions:IT WILL STAIN THE SKIN AFTER PROLONGED CONTACT. THE
STAIN WILL FADE IN TIME OR IT CAN BE REMOVED BY RINSING THE HANDS
WITH A DILUTE SOLUTION OF BLEACH. SAFETY GOGGLES AND GLOVES MUST BE
WORN WHILE USI NG THIS PRODUCT.

Respiratory Protection:NOT NORMALLY NEEDED. IF EXPOSURE LIMITS ARE
EXCEEDED, USE NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:NO SPECIAL REQUIREMENTS. IF EXPOSURE LIMITS ARE EXCEEDED,
PROVIDE ADEQUATE VENTILATION.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . IMPERVIOUS CLOTHING AS NECESSARY TO PREVENT SKIN CONT.
Work Hygienic Practices:WASH BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health

Boiling Pt:=100.C, 212.F
Vapor Density:>1 (AIR=1)
pH:1.5
Evaporation Rate & Reference:<1 (ETHER =1)
Solubility in Water:COMPLETE
Appearance and Odor:DARK BROWN LIQUID, SWEET ODOR.
Percent Volatiles by Volume:66

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS LIKE LIQUID CHLORINE AND CONCENTRATED OXYGEN.
Stability Condition to Avoid:OPEN FLAMES AND RED HOT SURFACES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER TOXIC FUMES.

Waste Disposal Methods:INCINERATE OR LANDFILL ABSORBED MATERIAL.
TREATMENT STANDARDS FOR IGNITABLE, CORROSIVE WASTE AND BARIUM MUST
BE MET FOR DISPOSAL, IF APPLICABLE. CHECK LOCAL, STATE AND FEDERAL
REGULATIONS.

Toxicological Information:PRIMARY ROUTE OF EXPOSURE UNDER NORMAL USE:
INHAL, SKIN & EYE CONT. ACUTE EFTS: SEV EYE & SKIN IRRITANT, MAY
CAUSE BURNS. EXCESS INHAL OF VAPS MAY RSLT IN DIZZ, HDCH & OTHER
CNS EFTS. CHRONIC EFTS: PR LNGD/RPTD SKIN CONT MAY DEFAT SKIN &
CAUSE DERM. RPTD OVEREXP TO ETHYLENE CAN CAUSE KIDNEY AND LIVER
EFTS. OTHER INFO: AS PER 29 CFR 1910.1200 (HAZARD COMMUNICATION),
THIS PROD CNTNS NO CARCINS AS LIS TED IN NTP, IARC, OR OSHA.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:IN DETERMINING EVNIRONMENTAL MOBILITY, CONSIDER THE
PRODUCT'S PHYSICAL AND CHEMICAL PROPERTIES (SEE SECTION PHYSICAL
AND CHEMICAL PROPERTIES.

Transport Information:TDG: FLAMM LIQ, N.O.S.(CNTNS ISOPROPANOL), 3.3,
UN 1993, III. IMDG: FLAMM LIQ, N.O.S. (CNTNS ISOPROPANOL), CLASS
3.3, UN1993, III, ERG NO 27 OR 128, EMS NO. 3-07, MGAG NO.
SUBSECTION 4.2 OF MFAG. IATA /ICAO: FLAMM LIQ, N.O..S.(CNTNS
ISOPROPANOL), CLASS 3, UN1993, III. ADR/RID: 1993 FLAMM LIQ,
N.O.S., 3, 31(C), ADR. U.S. DOT: SHIPPING NAME: 1 FLAMM LIQS,
NO.O.S.*. HAZ CLASS: 3. UN/NA#: UN1993. PACKA GING GROUP #: III.
EMER RESPONSE GUIDE BOOK NO 27 OR 128 *(CNTNS ISOPROPANOL). 1 NOTE:
SHIPPED AS CONSUMER COMMODITY ORM-D IN PACKAGING HAVING RATED
CAPACITY GROSS WT OF 66 LBS OR LESS (49 CFR 173.150 (C)).

SARA Title III Information:US EPA SARA TITLE III: 312 HAZARDS:
IMMEDIATE, DELAYED, FIRE. 313 CHEMICAL: ETHYLENE GLYCOL 15-25%.
BARIUM COMPOUND 1-5%.
Federal Regulatory Information:EUROPEAN CLASSIFICATION: C - CORROSIVE.
R-PHRASE(S): CAUSES BURNS. FLAMM. HARMFUL BY INHAL & IF SWALLOWED.
CANADIAN CLASSIFICATION: E: CORR MATL, B2: FLAMM LIQ. RISK
PHRASE(S): CAUSES BURNS. HARMFUL B Y INHAL & IF SWALLOWED.
S-PHRASE/PRECAUTIONARY MEASURE(S): DO NOT BREATHE VAP/SPRAY. USE
ONLY IN WELL-VENTILATED AREA. WEAR SUITABLE GLOVES & EYE/FACE PROT.
IN CASE OF CONT W/EYES, RINSE IMMED W/PLENT Y OF WATER & SEEK MED
ADVICE. IN CASE OF ACCIDENT OR IF YOU FELL UNWELL, SEEK MED ADVICE
IMMED (SHOW LBL WHERE POSSIBLE).